Snow and Ice and Other Winter Hazards - Tire Review Magazine

Snow and Ice and Other Winter Hazards

In some parts of the country, winter means snow-packed driveways, icy stairs, wet floors, roof collapse and frozen pipes.

Zurich advises business owners to not wait until it’s too late to prepare for winter emergencies.

Snow-related roof failures continue to be a common occurrence every year, resulting in hundreds of millions of dollars in losses to businesses. These collapses indicate that not all building codes have addressed the snow-load problem adequately.

Quality of construction, lack of inspection and proper maintenance are factors contributing to these structural failures, as well as the following:

• Discontinuous heating of structures can cause melting, refreezing and subsequent ice build up.

• Sloped warm roofs can cause refreezing on cold eaves, leading to ice dams or backup of ice under shingles.

• Wind-driven snow creates drifting, which significantly increases snow loads.

• Barrel vault and saw-tooth roofs collect excess snow and ice in valleys.

• Rain on top of heavy snowfall significantly increases the load, which can lead to structure failure.

• Ponding can occur when water backs up on roofs and in drainage systems.

Snow/Ice Load Recommendations

• Make a visual examination of the roof’s structural members, if possible. Check for leaks, sagging or misalignment; corroded, cracked and/or buckled steel members; split and/or rotted timber; and cracked and/or spalled concrete members.

• All drains, gutters and downspouts should be cleared of debris.

• Roofs must be routinely checked for ponding. Low areas should be repaired and/or additional drains added.

• If the building is left unheated for long periods, ensure the roof will be capable of withstanding any additional snow load.

• If lower roofs, canopies or covered walk-ways have been added to the structure, the effects of sliding and drifting snow should be considered.

• Increased snow loads and additional dead load due to reduced melting must be considered for any roof retrofitted with additional insulation for energy conservation reasons.

• The roof should be capable of withstanding additional sliding and drifting snow loads where solar panes, mechanical equipment or other roof projections have been added.

• Dead loads, such as air conditioners, heaters and suspended storage platforms, when added to the roof’s structural members, will decrease the roof’s live load capacity.

Frozen Water Pipes

Water freezes at 32°F, and so will your water pipes if not properly protected.

Frozen water pipes often burst when they thaw and can flood your business. Nothing dampens the spirit faster than waiting for a plumber inside a flooded building, so protect your facility against freezing temperatures with these tips:

• Below-freezing temperatures occur even in the southern states – don’t be complacent.

• Inspect all heaters and furnaces prior to cold weather.

• Conduct a thorough building inspection in the Fall and look for insufficient insulation in walls, attic, basement or other concealed spaces; openings in the roof or exterior walls where cold air could enter; exposed water pipes above drop ceilings, in attics or adjacent to large exterior doors; or interior areas where heat may be insufficient to protect water pipes.

• Inspect automatic (fire protection) sprinkler systems to ensure they are fully operational.

• If sprinkler equipment is located in a small room or closet, provide a separate heat source.

• Remember to leave the heat on over weekends and holidays when buildings are unoccupied.

• Don’t attempt to thaw pipes with any type of open flame; this creates a severe fire hazard.

Premises

Slip and fall incidents involving customers and employees also occur more frequently due to inclement weather. Don’t wait until winter hits your part of the country to prepare for the worst.

• Prepare for ice and snow in advance.

• Develop and implement a snow and ice removal program.

• Designate an individual to monitor weather and walking surface conditions.

• Have appropriate equipment, tools and supplies ready for use by internal personnel.

• Contract or retain professional snow removal companies in advance.

• Make sure the snow removal service provides regular checks on your location, with 24-hour and on-call capabilities.

• Record pertinent data on a snow/ice removal log.

• Allow sufficient time for treatment to take full effect.

• Remove highly-piled snow where it reduces visibility in traffic areas, especially at corners.

• Provide adequate lighting for all pedestrian and customer traffic areas.

• Redirect downspouts that empty onto walkways, as they can create slip and fall hazards.

• Don’t leave floor spills and puddles unattended, especially in customer traffic areas.

• Post a “Caution-Wet Floor” sign and clean wet floors immediately.

• Place mats or rugs at all entrances to help keep the floors clean and dry.

• Post other appropriate warning signs in high hazard areas.

• Remove or provide warnings of “hidden” hazards that could be inadvertently struck by cars or pedestrians if covered by snow (curbs, grates, debris in walkway, fire hydrants, etc.).

• Attend to injured persons immediately – show compassion but never admit fault.

• Conduct prompt accident/incident investigations.

 

For more information about this topic, contact the Zurich Risk
Engineering Department at 800-821-7803. For more information on any of
Zurich’s products or services, visit zurichna.com/zdu. Copyright 2011
Zurich American Insurance Co.

You May Also Like

Tire Industry Labor Shortage: Improve This to Keep Employees

I’ve spoken to many representatives from manufacturers, wholesalers and retailers who report that techs, counter people, drivers and even white-collar team members have walked off the job, failed to report, or given notice, and their businesses have been impacted by these departures. This isn’t just a tire industry issue—and goes beyond the tech shortage that

Tire Industry-Labor Shortage-Great-Resignation

I’ve spoken to many representatives from manufacturers, wholesalers and retailers who report that techs, counter people, drivers and even white-collar team members have walked off the job, failed to report, or given notice, and their businesses have been impacted by these departures. This isn’t just a tire industry issue—and goes beyond the tech shortage that has plagued the industry for decades.

Consider Software Solutions to Streamline Operations

Representatives from several software providers share how solutions drive efficiency and profitability, as well as what to look for when considering a system in your shop.

software-solutions-stock
How Data, Analytics Can Boost Profitability for Tire Retailers

By collecting and analyzing data about a dealer’s sales history, inventory levels and market demand, data and analytics platforms can analyze the performance of each dealer’s store and recommend actionable improvement opportunities.

How to Start the PPP Loan Payback Process

For many PPP loan recipients, it is time to start the repayment process—or file for PPP loan forgiveness. Read on to find out which portion of your loan may be forgivable and how to apply for forgiveness, as well as how to start the repayment process.

Creating a Positive Work Environment

Larry Sutton of RNR Tire Express shares seven different practices that have helped him create a positive work environment.

Other Posts

Using Data to Enrich the Customer Experience

Attaching data or a number to a vehicle’s service record adds a level of transparency to the discussion, and moves it from an “opinionated upsell” to a true, fact-based service need.

Coats Tread Depth Data
Microlearning Makes the Tire Industry Smarter, More Profitable

Microlearning modules can be customized to company and team member needs, where participants can learn through their own experiences and at their own pace.

Setting Up for Success: The Importance of Onboarding New Employees

Onboarding serves to not only give a new employee practical information that they will need in the job, but having that information gives them confidence as they start out in their new position.

employee-onboarding
Online Reputation Management

Eighty-eight percent of consumers trust online reviews as much as they trust personal recommendations.

Online-Business-Management